Zlin Z-37 Čmelák

Z-37 Čmelák
Z-37 Čmelák
	UK-registered Z-37A-2
General information
Type	Agricultural aircraft
Manufacturer	Let, Moravan
Status	In use
Primary user	Czechoslovak civilian aviation
Number built	~713
History
Manufactured	1965–1987
First flight	29 June 1963

The Zlin Z-37 Čmelák (Czech: "Bumblebee"), also known as LET Z-37 Čmelák, is an agricultural aircraft which was manufactured in Czechoslovakia. It is powered by a Soviet-built Ivchenko reciprocating engine. The aircraft is used mainly as a cropduster.

Design and development

Design work on a purpose-designed agricultural aircraft started in Czechoslovakia in 1961, with a cooperation of two manufacturers: Let Kunovice and Moravan (Zlin brand). The first prototype, designated as XZ-37, first flew on 29 March 1963 (other sources:29 June). It was a cantilever low-wing monoplane of tubular metal construction, the wings and stabilizers covered with duralumin and the fuselage and control surfaces made of fabric. It had a fixed undercarriage with a fully castoring tailwheel, but locked to the rudders for ground handling. The pilot's cockpit was in front, immediately behind a 315 hp radial engine, with a hopper for chemicals situated behind the cockpit. This offered the pilot a good view, but was potentially dangerous in case of an emergency landing. A mechanic could be seated behind the hopper, facing backwards. There were also spray booms mounted under the wings. There is also a freight version with open space instead of hopper and spray equipment and a -3 variant with three passenger seats facing rearwards.^{[citation needed]}

The aircraft was produced from 1965 under the designation Z-37. From 1971, the Z-37A was produced, with a strengthened construction. It was produced until 1975, and then in 1983-1984. A total of 677 were produced, including 27 two-seater Z-37A-2s for crew training.^{[citation needed]}

On 6 September 1981 the prototype XZ-37T first flew, powered by a (691 shp) Walter M-601B turboprop engine. Two further prototypes of the definitive turboprop version, the Z-37T Agro Turbo, powered by a less powerful M-601Z engine, flew on 12 July and 29 December 1983. As well as the new engine, it had longer-span wings (13.63 m) fitted with winglets.

The Z-37T was produced from 1985 until 1994, with a total of 51 aircraft built; including some Z-37T-2 two-seater trainers. Later production aircraft were redesignated Zlin Z-137T.

Operational history

The main user of Z-37s was Czechoslovakia (now the Czech Republic and Slovakia) along with East Germany and other Eastern Bloc countries. Many were exported to the Sudan and India and flown there almost non-stop with the hopper used as extra fuel tank. Variants are as far afield as England and the United States. Current use is limited because of fuel costs and is now used mainly in Slovakia.^[when?] Many are used for glider towing, having the ability to easily tow two gliders and often transport four gliders in tow for cross country.^{[citation needed]}

A record has been set by a Z 137T in Slovakia, towing nine two-seat gliders.

In early August 2025, during the Russian invasion of Ukraine, a modified version of the Z-37T has appeared carrying a pair of R-73 air-to-air missiles. According to the Commander-in-Chief of the Armed Forces of Ukraine, General Oleksandr Syrskyi, the AFU is making use of light aircraft to intercept Shahed drones.

Variants

XZ-37: First prototype.

Z-37: First production version built between 1965 and 1971.

Z-37A: Second production version with strengthened construction. Built between 1971 and 1975 and later between 1983 and 1984, 650 built.

Z-37A-2: Two-seat version for crew training, 27 built.

Z-37A-3: Pilot plus three passenger version. Conversion of "A" version. Rear-facing seats.

XZ-37T: Prototype of the turboprop version powered by Walter M-601B engine, built in 1981.

Z-37T Agro Turbo: Turboprop version with bigger span wings, powered by Walter M-601Z engine and built between 1985 and 1987. 28 built including Z-37T-2 trainer.

Z-37T-2: Two-seat turboprop version for crew training built between 1985 and 1987.

Z-137T: Further development version.

Operators

The Zlín Z-37 has been used extensively in former Eastern Bloc countries, including its country of manufacture Czechoslovakia (Slov-Air being a major operator), Bulgaria, East Germany and Hungary. It also saw service in Finland, India, Iraq and Yugoslavia.^{[citation needed]}

In August 2025, at least one Z-137AT with Ukrainian Army Aviation markings and armed with a pair of R-73 air-to-air missiles was spotted, reportedly to intercept Russian drones.

Aircraft on display

Bulgaria

Zlin Z-37A LZ-3007 at the Aviation Museum in Plovdiv.

Czech Republic

06-15 – Let Z-37A DDR-SNK at the Letecké Muzeum Kunovice in Kunovice.
006 – Let Z-37TM OK-078 at the Letecké Muzeum Kunovice. A prototype of the turboprop version, originally militarised but later converted to civil use.

Estonia

Zlin Z-37 at Estonian Aviation Museum

Germany

04-07 – Zlin Z-37A D-ESMU at the Technik Museum Sinsheim
08-18 – Let Z-37A D-ESOZ at the Deutsches Museum Flugwerft Schleissheim, Oberschleissheim, near Munich
14-20 – Zlin Z-37A D-ESLQ at Cottbus Air Base Museum.
20-06 – Zlin Z-37A DM-SVB at Cottbus Air Base Museum.

Latvia

Zlin Z-37A - OK-ZKC at Riga Aviation Museum

New Zealand

010 – Let Z-37T Agro Turbo ZK-DOZ at the Ashburton Aviation Museum in Ashburton, Canterbury.

Serbia

08-19 – Let Z-37A YU-BGL at the Museum of Aviation in Belgrade.

Specifications (Z-37A (agricultural version))

Data from Jane's All the World's Aircraft 1976-77.

General characteristics

Crew: one, pilot
Capacity: 1, mechanic (optional) / 650 L (170 US gal; 140 imp gal) or 600 kg (1,300 lb) of chemicals
Length: 8.55 m (28 ft 1 in)
Wingspan: 12.22 m (40 ft 1 in)
Height: 2.9 m (9 ft 6 in)
Wing area: 23.8 m² (256 sq ft)
Airfoil: root: NACA 33015; tip: NACA 44012A
Empty weight: 1,043 kg (2,299 lb)
Gross weight: 1,850 kg (4,079 lb)
Max takeoff weight: 1,850 kg (4,079 lb)
Fuel capacity: 125 L (33 US gal; 27 imp gal) in standard left hand centre-section tank, with optional 125 L (33 US gal; 27 imp gal) in right hand centre-section.

Provision for two externally carried fuel transport tanks of 125 L (33 US gal; 27 imp gal) each, for refuelling on site.

Powerplant: 1 × Avia M462RF 9-cylinder air-cooled supercharged radial piston engine, 235 kW (315 hp)
Propellers: 2-bladed Avia V 520 constant speed propeller

Performance

Maximum speed: 210 km/h (130 mph, 110 kn)
Cruise speed: 170 km/h (110 mph, 92 kn) at 1,500 m (4,900 ft)
Operating speed: 120 km/h (75 mph; 65 kn)
Stall speed: 90 km/h (56 mph, 49 kn) flaps up

81 km/h (50 mph; 44 kn) flaps down

Never exceed speed: 270 km/h (170 mph, 150 kn)
Rate of climb: 3.7 m/s (730 ft/min)
Wing loading: 77.7 kg/m² (15.9 lb/sq ft)
Power/mass: 0.077 hp/lb (0.127 kW/kg)
Minimum ground turning radius: 5.68 m (18.6 ft)
Take-off run: 150 m (490 ft)
Landing run: 122 m (400 ft)

References

↑ Industry Observer, Aviation Week & Space Technology, September 23, 1963, v. 79, no. 13, p. 23.
1 2 Taylor 1976, p. 30
↑ Mau 1987, p. 128
↑ Taylor 1988, p. 52
↑ "History of production of ZLIN aircraft". Zlin Aircraft. Archived from the original on October 24, 2007. Retrieved 2008-11-03.
↑ Taylor 1996, p. 389
↑ "Zlin 137t towing nine gliders". YouTube. 6 February 2009. Archived from the original on 2021-12-21. Retrieved January 23, 2019.
↑ "Crop Duster Armed With Air-To-Air Missiles Appears In Ukraine". The War Zone. 8 August 2025. Retrieved 8 August 2025.
1 2 Yan, Oleksandr (8 August 2025). "Ukraine Starts Using Light-Engine Ersatz Fighters". Militarnyi. Retrieved 9 August 2025.
↑ "AIRCRAFTS [sic] COLLECTION". Aviation Museum. Retrieved 9 July 2018.
↑ "Let Z-37 Čmelák". Letecké Muzeum Kunovice. 9 July 2019.
↑ "Let Z-37TM, OK-078 / 006, Slovacke Letecke Muzeum". ABPic. Air Britain. 4 June 2024. Retrieved 20 October 2024.
↑ "Zlin Z-37A Cmelak - Untitled". Airliners.net. VerticalScope Inc. 13 September 2019. Retrieved 20 October 2024.
↑ "LET Z-37 Cmelak, D-ESOZ / 08-18, Deutsches Museum - Flugwerft Schleissheim". ABPic. Air Britain. 10 September 2014. Retrieved 21 October 2024.
↑ "Zlin Z-37A Cmelak - Untitled". Airliners.net. VerticalScope Inc. 2 May 2019. Retrieved 21 October 2024.
↑ "Zlin Z-37 Cmelak DM-SVB". Rod's Aviation Photos. 2016. Retrieved 21 October 2024.
↑ "Zlin Agri-Plane". Ashburton Aviation Museum. The Ashburton Aviation Museum. Retrieved 9 July 2018.
↑ "Muzej Yugoslovenskog Ratnog Vazduhoplovstva". AviationMuseum.eu. Retrieved 9 July 2018.
↑ Taylor 1976, pp. 30–31
↑ Lednicer, David. "The Incomplete Guide to Airfoil Usage". m-selig.ae.illinois.edu. Retrieved 16 April 2019.

Mau, Hans-Joachim (1987). Tschechoslowakische Flugzeuge : von 1918 bis heute (in German) (1st ed.). Berlin: Transpress. ISBN 3-344-00121-3.
Taylor, J. W. R., ed. (1976). Jane's All the World's Aircraft 1976-77. London: Macdonald and Jane's. ISBN 0-354-00538-3.
Taylor, J. W. R., ed. (1988). Jane's All the World's Aircraft 1988-1989. Coulsden, Surrey, UK: Jane's Information Group. ISBN 0-7106-0867-5.
Taylor, Michael, ed. (1996). Brassey's World Aircraft & Systems Directory 1996/97 Edition. London: Brassey's. ISBN 1-85753-198-1.

External links

Photos of Čmelák in action Archived 2007-10-08 at the Wayback Machine
Photos at Airliners.net
Photo and description^{[permanent dead link]} (in Slovak)

[1] Industry Observer, Aviation Week & Space Technology, September 23, 1963, v. 79, no. 13, p. 23.

[Janes_76_p30-2] 1 2 Taylor 1976, p. 30

[3] Mau 1987, p. 128

[Janes_88_p52-4] Taylor 1988, p. 52

[5] "History of production of ZLIN aircraft". Zlin Aircraft. Archived from the original on October 24, 2007. Retrieved 2008-11-03.

[Brassey's_96_p389-6] Taylor 1996, p. 389

[7] "Zlin 137t towing nine gliders". YouTube. 6 February 2009. Archived from the original on 2021-12-21. Retrieved January 23, 2019.

[8] "Crop Duster Armed With Air-To-Air Missiles Appears In Ukraine". The War Zone. 8 August 2025. Retrieved 8 August 2025.

[Militarnyi-9] 1 2 Yan, Oleksandr (8 August 2025). "Ukraine Starts Using Light-Engine Ersatz Fighters". Militarnyi. Retrieved 9 August 2025.

[10] "AIRCRAFTS [sic] COLLECTION". Aviation Museum. Retrieved 9 July 2018.

[11] "Let Z-37 Čmelák". Letecké Muzeum Kunovice. 9 July 2019.

[12] "Let Z-37TM, OK-078 / 006, Slovacke Letecke Muzeum". ABPic. Air Britain. 4 June 2024. Retrieved 20 October 2024.

[13] "Zlin Z-37A Cmelak - Untitled". Airliners.net. VerticalScope Inc. 13 September 2019. Retrieved 20 October 2024.

[14] "LET Z-37 Cmelak, D-ESOZ / 08-18, Deutsches Museum - Flugwerft Schleissheim". ABPic. Air Britain. 10 September 2014. Retrieved 21 October 2024.

[15] "Zlin Z-37A Cmelak - Untitled". Airliners.net. VerticalScope Inc. 2 May 2019. Retrieved 21 October 2024.

[16] "Zlin Z-37 Cmelak DM-SVB". Rod's Aviation Photos. 2016. Retrieved 21 October 2024.

[17] "Zlin Agri-Plane". Ashburton Aviation Museum. The Ashburton Aviation Museum. Retrieved 9 July 2018.

[18] "Muzej Yugoslovenskog Ratnog Vazduhoplovstva". AviationMuseum.eu. Retrieved 9 July 2018.

[Janes_76_p30-1-19] Taylor 1976, pp. 30–31

[Selig-20] Lednicer, David. "The Incomplete Guide to Airfoil Usage". m-selig.ae.illinois.edu. Retrieved 16 April 2019.

v t e Aircraft produced by Zlín and Moravan
Manufacturer designations	Z-I Z-II Z-III Z-IV Z-V Z-VI Z-VII Z-VIII Z-IX Z-X Z-XI Z-XII Z-XIII Z-13 Z-XIV Z-XV Z-XVI Z-XVII¹ Z-XVIII Z-XIX¹ Z-20 Z-XXI/21 Z-22 Z-23¹ Z-24 Z-25 Z-26 Z-27¹ Z-28 Z-29¹ Z-30 Z-31¹ Z-32 Z-33 Z-34 Z-35 Z-36 Z-37 Z-38 Z-39 Z-40¹ Z-41 Z-42 Z-43 Z-44 Z-45 Z-46 Z-47 Z-48 Z-49¹ Z-50 Z-51 Z-52 Z-53 through Z-59¹ Z-60 Z-61 Z-62 through Z-89¹ Z-90 Z-91 through Z-112¹ Z-113 Z-114 through Z-119¹ Z-120 Z-121¹ Z-122 Z-123¹ Z-124¹ Z-125 Z-126 Z-127 through Z-134¹ Z-135 Z-136¹ Z-137 Z-138 through Z-141¹ Z-142 Z-143 Z-144 through Z-180¹ Z-181 Z-182 through Z-211¹ Z-212 Z-213 through Z-224¹ Z-225 Z-226 Z-227 through Z-241¹ Z-242 Z-243 through Z-280¹ Z-281 Z-282 through Z-311¹ Z-312 Z-313 through Z-324¹ Z-325 Z-326 Z-327 through Z-380¹ Z-381 Z-382 through Z-399¹ Z-400 Z-401 through Z-425¹ Z-426 Z-427 through Z-525¹ Z-526 Z-527 through Z-625¹ Z-626 Z-627 through Z-725¹ Z-726
By name	Akrobat Čmelák Derviš Junak Savage Šohaj Trener Trener-Master
¹ Unknown/not assigned